Air compressor manufacturers remind: air compressor maintenance can not delay time.

2024-03-22

Most air compressor maintenance staff will encounter such a situation, and users will delay maintenance time and cause greater losses. Generally, the sales staff of air compressor manufacturers will remind users that it is time to carry out maintenance on time without delay.

But why do users delay? Through understanding, we know that: 1. The factory is busy in production. 2. Delayed maintenance can save more money. In fact, delaying the maintenance of air compressor will not only save money, but also cost more, because the air compressor will increase the electricity bill if it is not maintained in time. How to affect the energy efficiency of air compressor in terms of three filters and one oil.

1. Air filter

Air filters should be replaced in time after being used for a period of time, especially for manufacturers with poor environment. If the filtration effect is poor, or the air filtration efficiency is low, a large amount of dust will be absorbed on the oil surface after inhalation, which will lead to the rapid rise of oil pressure difference and increase power consumption. The air compressor manufacturer reminds the air compressor to clean the air filter every 1000 hours. If the air filter is not cleaned or replaced in time, the air filter will be blocked, the suction resistance will increase, the energy efficiency of the air compressor will be lower, and electricity will be wasted.

2. Oil filter

Oil filtration is the principle of adsorption filtration, and the smaller the resistance, the higher the energy efficiency. The filtering effect of oil filter mainly depends on the dust capacity, so it should be cleaned in time. The air compressor runs for 500 hours for the first time, and then runs for 4000 hours. Every time the lubricating oil is replaced, the oil filter element is also replaced.

3. Oil-gas separation core

The main function of oil-gas separator is to separate the oil in compressed air and ensure the quality of compressed air. Overtime use will not only affect the product, but also increase the operating cost and even lead to host failure.

4. Lubricating oil

After the lubricating oil of air compressor is used for a long time, it may cause the equipment to stop due to high temperature alarm, coking and carbon deposition in the main engine.

If the "three filters and one oil" of the air compressor exceeds the service life, there will be an early warning signal during operation, but it will not stop. Please contact the after-sales service personnel of the air compressor manufacturer for maintenance as soon as possible, so don't lose too much for too little.

WhatsApp: +86 15317057736